AC Leaking Water in San Carlos

AC Leaking Water in San Carlos

Every AC pulls moisture out of the air as it cools, and that water is supposed to run down the evaporator coil, into the drain pan, and out through the condensate line. A leak means that path broke somewhere: a clogged line backing water up over the pan, a cracked or rusted-through pan, a failed condensate pump, or a float safety switch that should have shut the system down before water ever reached the ceiling or the closet floor. Where the water actually shows up, a ceiling stain, a puddle by the air handler, or a system that has simply shut itself off, is usually the first clue to which part failed. The detail that matters in San Carlos is the hill-to-flat load split and the longer hillside line-set runs.

Two local facts shape how a leak like this plays out here. San Carlos runs the same hill-to-flat split as its neighbors: the flats near El Camino stay mild, while the hillside neighborhoods above White Oaks and Devonshire catch more sun and carry a noticeably warmer load in the afternoon. Housing mixes 1940s and 50s ranches on the flats with larger custom homes built from the 1960s on in the hills. The hillside homes usually mean longer line-set runs and equipment mounted on a terraced pad, a different job than a flat, easy-access install on the valley floor.

In San Carlos, we don't call a leak fixed until we've watched a full cycle drain clean with the pan dry at the end. The written estimate lays out exactly which part failed, whether that's the line, the pan, the pump, or the float switch, before any repair goes forward. The $99 diagnostic fee is credited toward the repair.

Common causes

Clogged condensate drain line. Algae and dust build up inside the drain line over time until it backs up and overflows the pan instead of draining outside. This is the single most common cause of an AC leak, and it is usually a quick fix once we get to it.

Cracked or rusted-through drain pan. Metal pans rust through with age, and plastic pans crack as they age too. Once the pan itself is compromised, even a clear drain line will not stop the leak.

Failed condensate pump. On systems where gravity cannot drain the line, a condensate pump lifts the water out. When the pump fails, the water has nowhere to go but up and over the pan.

Stuck or failed float safety switch. The float switch is supposed to shut the system down before an overflow reaches the ceiling. When it sticks or fails, that safety net is gone, which is exactly when we see real water damage instead of a shutdown.

Frozen coil that melts off. A partially frozen evaporator coil can look like a drainage problem when it thaws between cycles and sheds more water than the pan and drain were built to handle at once. We check for ice and airflow restriction alongside the drain itself.

How we diagnose it

• Trace the water to confirm it is condensate and not a roof or plumbing leak before opening anything up.
• Clear and flush the condensate line, then watch it drain fully under a running cycle.
• Inspect the primary and, where present, secondary pan for cracks, rust-through, and standing water.
• Test the float safety switch and, on pump-assisted systems, the condensate pump itself under load.
• Check airflow and refrigerant charge to rule out a frozen coil shedding water faster than the drain can handle. Hillside homes here often carry longer, more convoluted duct runs than a flat-lot house, which makes a restriction easier to hide.

$99 diagnostic, credited toward the repair. You get a written quote before any work begins.

AC Leaking Water in San Carlos: common questions

Nearby and related

AC Leaking Water near San Carlos: Belmont · Redwood City .

This is usually a ac repair in San Carlos job. See our ac repair overview or the San Carlos service area.