AC Leaking Water in South San Francisco

AC Leaking Water in South San Francisco

Every AC pulls moisture out of the air as it cools, and that water is supposed to run down the evaporator coil, into the drain pan, and out through the condensate line. A leak means that path broke somewhere: a clogged line backing water up over the pan, a cracked or rusted-through pan, a failed condensate pump, or a float safety switch that should have shut the system down before water ever reached the ceiling or the closet floor. Where the water actually shows up, a ceiling stain, a puddle by the air handler, or a system that has simply shut itself off, is usually the first clue to which part failed. The detail that matters in South San Francisco is the fog-line split between the old flatland neighborhoods and hillside Westborough.

Two local facts shape how a leak like this plays out here. South San Francisco sits under heavy fog for much of the year, especially in the older flatland neighborhoods below Sign Hill, while newer construction up in Westborough sits above the fog line and runs noticeably warmer. Neighborhoods like Winston Manor and Sunshine Gardens carry a lot of older housing built without ductwork, since nobody needed central air under that much fog. Westborough's newer hillside construction is a different story, built later and with more real cooling load to plan around.

In South San Francisco, we don't call a leak fixed until we've watched a full cycle drain clean with the pan dry at the end. The written estimate lays out exactly which part failed, whether that's the line, the pan, the pump, or the float switch, before any repair goes forward. The $99 diagnostic fee is credited toward the repair.

Common causes

Clogged condensate drain line. Algae and dust build up inside the drain line over time until it backs up and overflows the pan instead of draining outside. This is the single most common cause of an AC leak, and it is usually a quick fix once we get to it.

Cracked or rusted-through drain pan. Metal pans rust through with age, and plastic pans crack as they age too. Once the pan itself is compromised, even a clear drain line will not stop the leak.

Failed condensate pump. On systems where gravity cannot drain the line, a condensate pump lifts the water out. When the pump fails, the water has nowhere to go but up and over the pan.

Stuck or failed float safety switch. The float switch is supposed to shut the system down before an overflow reaches the ceiling. When it sticks or fails, that safety net is gone, which is exactly when we see real water damage instead of a shutdown.

Frozen coil that melts off. A partially frozen evaporator coil can look like a drainage problem when it thaws between cycles and sheds more water than the pan and drain were built to handle at once. We check for ice and airflow restriction alongside the drain itself.

How we diagnose it

• Trace the water to confirm it is condensate and not a roof or plumbing leak before opening anything up.
• Clear and flush the condensate line, then watch it drain fully under a running cycle.
• Inspect the primary and, where present, secondary pan for cracks, rust-through, and standing water.
• Test the float safety switch and, on pump-assisted systems, the condensate pump itself under load.
• Check airflow and refrigerant charge to rule out a frozen coil shedding water faster than the drain can handle. The fog-belt tract homes here were built with minimal or no ductwork, so a retrofit duct run is often undersized or improvised.

$99 diagnostic, credited toward the repair. You get a written quote before any work begins.

AC Leaking Water in South San Francisco: common questions

Nearby and related

AC Leaking Water near South San Francisco: San Bruno · Daly City · Millbrae .

This is usually a ac repair in South San Francisco job. See our ac repair overview or the South San Francisco service area.