AC Leaking Water in Foster City

AC Leaking Water in Foster City

Every AC pulls moisture out of the air as it cools, and that water is supposed to run down the evaporator coil, into the drain pan, and out through the condensate line. A leak means that path broke somewhere: a clogged line backing water up over the pan, a cracked or rusted-through pan, a failed condensate pump, or a float safety switch that should have shut the system down before water ever reached the ceiling or the closet floor. Where the water actually shows up, a ceiling stain, a puddle by the air handler, or a system that has simply shut itself off, is usually the first clue to which part failed. The detail that matters in Foster City is the fill soil settling under the ductwork and the damp lagoon-front air.

Two local facts shape how a leak like this plays out here. Foster City is built almost entirely on filled marshland reclaimed from the bay starting in the 1960s, laced with the lagoons the city is known for, and the lagoon-adjacent air runs damp even on a mild day. The housing is unusually uniform for the Peninsula: 1960s and 70s tract construction on engineered fill, much of it lagoon-front or a short walk from the water. Sixty years of settling in that fill soil has shifted more than a few slabs, which shows up as duct runs that no longer sit level and condensate lines that no longer drain the way they were installed.

In Foster City, we don't call a leak fixed until we've watched a full cycle drain clean with the pan dry at the end. The written estimate lays out exactly which part failed, whether that's the line, the pan, the pump, or the float switch, before any repair goes forward. The $99 diagnostic fee is credited toward the repair.

Common causes

Clogged condensate drain line. Algae and dust build up inside the drain line over time until it backs up and overflows the pan instead of draining outside. This is the single most common cause of an AC leak, and it is usually a quick fix once we get to it.

Cracked or rusted-through drain pan. Metal pans rust through with age, and plastic pans crack as they age too. Once the pan itself is compromised, even a clear drain line will not stop the leak.

Failed condensate pump. On systems where gravity cannot drain the line, a condensate pump lifts the water out. When the pump fails, the water has nowhere to go but up and over the pan.

Stuck or failed float safety switch. The float switch is supposed to shut the system down before an overflow reaches the ceiling. When it sticks or fails, that safety net is gone, which is exactly when we see real water damage instead of a shutdown.

Frozen coil that melts off. A partially frozen evaporator coil can look like a drainage problem when it thaws between cycles and sheds more water than the pan and drain were built to handle at once. We check for ice and airflow restriction alongside the drain itself.

How we diagnose it

• Trace the water to confirm it is condensate and not a roof or plumbing leak before opening anything up.
• Clear and flush the condensate line, then watch it drain fully under a running cycle.
• Inspect the primary and, where present, secondary pan for cracks, rust-through, and standing water.
• Test the float safety switch and, on pump-assisted systems, the condensate pump itself under load.
• Check airflow and refrigerant charge to rule out a frozen coil shedding water faster than the drain can handle. Sixty years of settling on filled bay soil here has left more than a few duct runs out of level or pinched at a joint.

$99 diagnostic, credited toward the repair. You get a written quote before any work begins.

AC Leaking Water in Foster City: common questions

Nearby and related

AC Leaking Water near Foster City: San Mateo · Belmont · Redwood City .

This is usually a ac repair in Foster City job. See our ac repair overview or the Foster City service area.